Product ID:MT STARTER (P-P) RP605Z, RP606Z, RP600Z, RP607
MSDS Date:05/24/1990
FSC:6850
NIIN:00N043451
MSDS Number: BSYVG

MINOLTA CORP

101 WILLIAMS DRIVE
RAMSEY, NJ 07446
US

Emergency Phone: 201-825-4000

Info Phone: 201-825-4000

Cage: GO339

MINOLTA CORPORATION

RAMSEY, NJ 07446 US

Telephone: 201-825-4000

Cage: 23736

CARRIER (CONSISTS OF INGREDIENTS 2 - 4)

Fraction By Weight: >90%

OSHA PEL N/K

ACGIH TLV: N/K

FERRITE; (FERROSPINEL)

CAS: 1317-54-0

RTECS: LK0495000

OSHA PEL N/K

ACGIH TLV: N/K

POLYESTER RESIN

OSHA PEL N/K

ACGIH TLV: N/K

CARBON BLACK

CAS: 1333-86-4

RTECS: FF5800000

OSHA PEL 3.5 MG/M3

ACGIH TLV: 3.5 MG/M3

TONER (CONSISTS OF INGREDIENTS 6 - 8)

Fraction By Weight: <10%

OSHA PEL N/K

ACGIH TLV: N/K

STYRENE ACRYLATE COPOLYMER

OSHA PEL N/K

ACGIH TLV: N/K

COPPER OXIDE

CAS: 1317-38-0

RTECS: GL7900000

OSHA PEL N/K

ACGIH TLV: N/K

CARBON BLACK

CAS: 1333-86-4

RTECS: FF5800000

OSHA PEL 3.5 MG/M3

ACGIH TLV: 3.5 MG/M3

LD50 LC50 Mixture:LD50:(ORAL,RAT) >5 G/KG.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:MINIMAL RESP TRACT IRRIT MAY
OCCUR AS W/EXPOS TO LG AMTS OF ANY NONTOXIC DUST. MAY CAUSE COUGH &
RAISE PHLEGM. CHRONIC:NONE. TONER PRESENTS LOW HAZ FOR USUAL OCCUP
SETTINGS. BASED ON AVAIL DATA, HUMAN EXPOS TO TONER HAS BEEN SHOWN
TOCAUSE MINIMAL RESP TRACT IRRIT AS MAY OCCUR AS W/LG AMTS OF (EFTS
OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:NONTOXIC DUSTS. RSLTS OF ONE ANIMAL
STUDY WHERE RATS INHALED TONER THAT WAS TEN TIMES MORE RESPIRABLE
THAN COMMERICIALLY AVAIL TONER WERE OBSERVED TO HAVE NO LUNG
CHANGES AT LOW EXPOS (MOST R ELEVANT LEVEL TO POTNTL HUMAN EXPOS).
AT HIGHER LEVELS SLIGHT DEGREE OF LUNG FIBROSIS WAS OBSERVED DUE TO
EXCESS(SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INHAL:WASH NOSTRILS, RINSE MOUTH. INGEST: DILUTE STOMACH
CONTENTS W/SEVERAL GLASSES OF WATER. EYES:FLUSH W/WATER FOR AT
LEAST 15 MINUTES. SKIN:WASH W/SOAP & WATER.

Extinguishing Media:WATER, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . AVOID INHALATION OF SMOKE.
Unusual Fire/Explosion Hazard:TONER, COMPONENT OF STARTER, IS
COMBUSTIBLE POWDER. WHEN DISPERSED IN AIR, IT FORMS EXPLOSIVE
MIXTURES.

Spill Release Procedures:IF SPILLED, SWEEP UP OR VACUUM.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:NONE
Other Precautions:NONE SPECIFIED BY MANUFACTURER.

Respiratory Protection:NONE REQUIRED WHEN USED AS INTENDED IN MINOLTA
EQUIPMENT. NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN .
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPRVD CHEM SAFETY GOGGLES .
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE
Supplemental Safety and Health
EFTS OF OVEREXP:AMOUNTS OF DUST RETAINED IN THE LUNGS FOR A PROLONGED
INTERVAL.

HCC:N1
Spec Gravity:2.9 (H2O=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK POWDER; FAINT ODOR.

Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:PRODUCTS OF COMBUSTION ARE TOXIC.
AVOID BREATHING OF SMOKE.

Waste Disposal Methods:DO NOT INCINERATE. NO SPECIAL TECHNIQUES BEYOND
NORMAL PRACTICE. ENSURE CONFORMITY W/FEDERAL, STATE & LOCAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.